Carrier COMFORTLINK P5030-100 Manuel d'utilisateur télécharger pdf

Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations.

Catalog No. 04-53480054-01 Printed in U.S.A. Form 48P-1SO Pg 1 4-09 Replaces: New

User’s Information Manual

NOTE TO INSTALLER:

This manual should be left with the equipment owner.

Your combination heating/cooling rooftop unit is equipped

with an automatic direct spark ignition system and induced-

draft power combustion blower.

TO LIGHT UNIT

See Fig. 1 for location of gas valve(s). Refer to Fig. 2 while

proceeding with the following steps.

1. Turn off the unit demand for cooling or heating by using

the scrolling marquee. The scrolling marquee is located in

the control box at the compressor end of the unit.

a. Push the key unit a blank display screen

is shown.

b. Push the key until the SERVICE TEST LED is

lit.

c. Push the key. The display will show

STOP.

d. Push the key again. The NO/YES display

will flash.

e. Push the or key to toggle the display to

YES and then push . The unit will be

locked off from heating, cooling or any operation.

The controls will still function and the display will

still operate.

2. Close the field-installed manual gas shutoff valve.

3. Turn off the electrical power to the unit using the optional

disconnect or the field-installed disconnect and lock off

using proper lockout and tag-out procedures.

4. Open the burner section hinged access door.

5. Move the switch on the gas valves to the OFF position

and wait 5 minutes.

NOTE: If this is the first installation of the unit, the gas

flue hoods must be installed before operating unit. These

must be installed for the unit to run properly.

6. Move the switch on the gas valves to the ON position.

7. Close the burner section hinged access door.

8. Turn on the electrical supply to the units.

9. Open the field-installed manual gas valve.

WARNING: If the information in this

manual is not followed exactly, a fire or

explosion may result causing property

damage, personal injury or loss of life.

— Do not store or use gasoline or other

flammable vapors and liquids in the

vicinity of this or any other appliance.

— WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch;

do not use any phone in your

building.

• Immediately call your gas supplier

from a neighbor’s phone. Follow the

gas supplier’s instructions.

• If you cannot reach your gas sup-

plier, call the fire department.

— Installation and service must be per-

formed by a qualified installer, service

agency or the gas supplier.

WARNING

Improper installation, adjustment, alteration, ser-

vice or maintenance can cause injury or property

damage. Refer to this manual. For assistance or

additional information consult a qualified installer,

service agency, or the gas supplier.

WARNING

Before performing recommended maintenance, be sure

main power switch to unit is turned off and lockout tag is

installed. Electrical shock could cause personal injury.

WARNING

Burners will light automatically. Do not attempt to light by

hand; personal injury may result.

DANGER

1. Do not turn off the electrical power to unit without

first turning off the gas supply.

2. Before attempting to start the gas heating section,

familiarize yourself with all the procedures that must

be followed.

3. Never attempt to manually light the burners on the

unit with a match, lighter, or any other flame. If the

electric sparking device fails to light the burners, refer

to the shutdown procedures, then call your dealer as

soon as possible.

If you do not follow these instructions exactly, a fire or

explosion may result, causing property damage, injury, or

loss of life.

ESCAPE

ENTER

48P2,P3,P4,P5030-100

Gas Heating/Electric Cooling Units

with COMFORTLINK™ Controls

1 2 3 4 5 6 7 8

Résumé du contenu

Page 1 - User’s Information Manual

Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations.Cata

Page 2 - 055-100 SIZES HIGH HEAT

210. Using the scrolling marquee, enable the unit to run usingthe following procedure:a. Push the key unit a blank display screenis shown.b. Push th

Page 3 - Fig. 2 — To Light Unit

3STEP 1Fig. 2 — To Light UnitSTEP 5STEP 4STEP 3STEP 2STEP 7STEP 6STEP 10STEP 8LOCK-OUTTAGONOFFMAINSTEP 9Run StatusService TestTemperaturePressuresSetp

Page 4

4TO SHUT UNIT OFFSee Fig. 1 for location of gas valve(s). Refer to Fig. 3 whileproceeding with the following steps.1. Turn off the unit demand for coo

Page 5 - LOCK-OUT

5When replacing your unit filters, always use the same sizeand type of filter that was originally supplied by the installer.Units with outdoor air cap

Page 6 - Fig. 4 — Door Locations

6POWEREXHAUSTOPTIONPOWER EXHAUSTACCESS DOOR(TYP BOTH SIDES)FILTERACCESSDOORACCESSDOORSGAS SECTIONACCESS DOORGASBURNERSAIRHOODSCONTROLBOXCONTROLBOXGAS

Page 7

7Fan and Belts — Periodically check the condition of fanwheels and housings and belt tension. When service is neces-sary, call your dealer.Evaporator-

Page 8 - IN CASE OF TROUBLE

Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations.Cata

Commentaires sur ces manuels

Pas de commentaire

Carrier COMFORTLINK P5030-100 Manuel d'utilisateur

Naviguer en ligne ou télécharger Manuel d'utilisateur pour Grilles Carrier COMFORTLINK P5030-100. Carrier COMFORTLINK P5030-100 User Manual Manuel d'utilisatio

Résumé du contenu

Commentaires sur ces manuels

Produits connexes et manuels pour Grilles Carrier COMFORTLINK P5030-100